Differences
This shows you the differences between two versions of the page.
| Both sides previous revision Previous revision Next revision | Previous revision Last revision Both sides next revision | ||
|
techtalk:evo:engctl01a [2018/06/30 00:46] hippysmack [EVO: Engine Control - Sub-01A] |
techtalk:evo:engctl01a [2020/10/16 16:03] hippysmack [Pics of 1998 Coil and Plug Wires] |
||
|---|---|---|---|
| Line 1: | Line 1: | ||
| [[:techtalk:menu|{{ :techtalk:gototechnicalmenu.jpg|}}]] | [[:techtalk:menu|{{ :techtalk:gototechnicalmenu.jpg|}}]] | ||
| - | ====== EVO: Engine Control - Sub-01A ====== | + | ====== EVO: Engine Control - Sub-01a ====== |
| - | ====== Finding TDC on Compression Stroke (1991-2003) ====== | + | ====== Pics of 1998 Coil and Plug Wires ====== |
| - | The bike must be on a jack or a lift so you can spin the rear wheel. \\ | + | Pics by Hippysmack\\ |
| - | Remove both spark plugs (or one on each cylinder for an "S" model). | + | |
| - | | Remove the timing plug (right side at the base between both cylinders) ((photos by Phillober of the XLFORUM http://xlforum.net/forums/showthread.php?t=1175659&highlight=tapping+threads&page=3)) || | + | {{:techtalk:evo:engctl:1998_1200s_coil_1_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_1200s_coil_2_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_1200s_coil_3_by_hippysmack.jpg?direct&300|}} \\ |
| - | |{{:techtalk:evo:engctl:finding_tdc_compression_1_by_phillober.jpg?direct&300|}}|{{:techtalk:evo:engctl:finding_tdc_compression_2_by_phillober.jpg?direct&300|}}| | + | |
| - | * With the rear wheel off the ground, shift into 1st gear. Then, rotate the rear wheel forward until it stops (this will turn over the engine / transmission). \\ You can also just turn the wheel over with one hand (a bump at a time) while shifting with the other. The wheel doesn't have to turn too far or at any rate of speed. | + | {{:techtalk:evo:engctl:1998_1200s_coil_4_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_1200s_coil_5_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_1200s_coil_6_by_hippysmack.jpg?direct&300|}} \\ |
| - | * Then you can shift thru 3rd. | + | |
| - | * It takes two separate movements of the shift forks to get into 4th which requires turning the wheel again. | + | |
| - | * Then you can shift to 5th. Of all the gears to be in, 5th will be the easiest to turn by hand. | + | |
| - | | Shifting the transmission into fifth gear ((photos by Phillober of the XLFORUM http://xlforum.net/forums/showthread.php?t=1175659&highlight=tapping+threads&page=3)) ||| | + | {{:techtalk:evo:engctl:1998_1200s_coil_and_plug_wires_1_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_1200s_coil_and_plug_wires_2_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_1200s_coil_and_plug_wires_3_by_hippysmack.jpg?direct&300|}} \\ |
| - | |{{:techtalk:evo:engctl:finding_tdc_compression_3_by_phillober.jpg?direct&300|}}|{{:techtalk:evo:engctl:finding_tdc_compression_4_by_phillober.jpg?direct&300|}}| {{:techtalk:evo:engctl:finding_tdc_compression_5_by_phillober.jpg?direct&300|}}| | + | |
| - | | When you take out the timing plug, \\ this is more than likely what you see ((photo by Phillober of the XLFORUM http://xlforum.net/forums/showthread.php?t=1175659&highlight=tapping+threads&page=3)) | TDC timing mark in center of window ((photo by Phillober of the XLFORUM http://xlforum.net/forums/showthread.php?t=1175659&highlight=tapping+threads&page=3)) | | + | {{:techtalk:evo:engctl:1998_1200s_coil_and_plug_wires_4_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_1200s_coil_and_plug_wires_5_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_1200s_coil_and_plug_wires_6_by_hippysmack.jpg?direct&300|}} \\ |
| - | |{{:techtalk:evo:engctl:finding_tdc_compression_6_by_phillober.jpg?direct&300|}}|{{:techtalk:evo:engctl:finding_tdc_compression_7_by_phillober.jpg?direct&300|}}| | + | |
| + | {{:techtalk:evo:engctl:1998_xl1200s_front_plug_wire_lengths_by_hippysmack.jpg?direct&300|}} {{:techtalk:evo:engctl:1998_xl1200s_rear_plug_wire_lengths_by_hippysmack.jpg?direct&300|}} \\ | ||
| - | | Using the "finger method" to feel compression ((photo by Phillober of the XLFORUM http://xlforum.net/forums/showthread.php?t=1175659&highlight=tapping+threads&page=3)) | | ||
| - | |{{:techtalk:evo:engctl:finding_tdc_compression_8_by_phillober.jpg?direct&300|}}| | ||
| \\ | \\ | ||
| - | [[:techtalk:menu|{{:techtalk:gototechnicalmenu.jpg|}}]] | ||
| + | [[:techtalk:menu|{{:techtalk:gototechnicalmenu.jpg|}}]] | ||
